T6 tail gate struts

[Phoenix387]

VW Transporter T6 Caravelle Uprated Bike Rack Tailgate / Boot Gas Strut - 7E0827550D

A single VW Transporter T6 Caravelle Uprated Bike Rack Gas Strut with a 2 year warranty and new fixings. Replaces part number(s) 7E0827550D

www.sgs-engineering.com

Bought from this company for my Audi A2 and Golf R32. Good quality, take minutes to fit and they hold the tailgate up easily.

 

[WelshGas]

VW Transporter T6 Caravelle Uprated Bike Rack Tailgate / Boot Gas Strut - 7E0827550D

A single VW Transporter T6 Caravelle Uprated Bike Rack Gas Strut with a 2 year warranty and new fixings. Replaces part number(s) 7E0827550D

www.sgs-engineering.com

Bought from this company for my Audi A2 and Golf R32. Good quality, take minutes to fit and they hold the tailgate up easily.

According to the specification only 1200N , so weaker than the standard California gas struts.
Designed to replace the weaker Transporter/Caravelle struts when fitting a Tailgate Bike Rack.

 

[Cali Phillip]

Interesting thread, this am our 2019 Ocean tailgate would not stray even part up, -4C. We have just the chairs and Thule 2 bike rack on, no bikes. Do the struts degrade over time I wondered, what do people think in this? Loathed to change them.

 

[Alan Andrews]

Interesting thread, this am our 2019 Ocean tailgate would not stray even part up, -4C. We have just the chairs and Thule 2 bike rack on, no bikes. Do the struts degrade over time I wondered, what do people think in this? Loathed to change them.

It is the cold weather.

 

[Cali Phillip]

It is the cold weather.

Yes, its ok down to zero.

 

[Andy C Berks.]

Yes, its ok down to zero.

Have you got the 1270N rated struts ? That’s what VW recommend for the bike rack and is also what the Ocean comes with nowadays (ours is MY2023). Mine needed a second push to stay up in the cold today, which is the first time have experienced that and this is the first winter with the bike rack. The strut rating is printed on them and will be a 4 digit no. followed by an N.

 

[TripleBee]

Interesting thread, this am our 2019 Ocean tailgate would not stray even part up, -4C. We have just the chairs and Thule 2 bike rack on, no bikes. Do the struts degrade over time I wondered, what do people think in this? Loathed to change them.

I have the 1250N struts, on my 2010 Cali. In summer the tailgate still lifts up completely with the chairs (I have no bike rack).
In winter, I have to push the tailgate completely open, but that was always the case. Then the tailgate stays up.
The bike rack is extra weight that might affect this.
What is the force rating on your struts?

 

[Cali Phillip]

Have you got the 1270N rated struts ? That’s what VW recommend for the bike rack and is also what the Ocean comes with nowadays (ours is MY2023). Mine needed a second push to stay up in the cold today, which is the first time have experienced that and this is the first winter with the bike rack. The strut rating is printed on them and will be a 4 digit no. followed by an

Will check the rating tomorrow

 

[Peachesenregalia]

Our California came with upgraded struts and in summer/higher temps with no bike rack on its hard to close the tailgate. Fitted bike rack and had two bikes on in europe and in warmer temps it stays up (just about) our bikes are carbon fibre road bikes so very light). Cold Winter in Ireland and the boot does require a little push up to fully open but stays up with rack but no bikes on but not with bikes. The obvious tip is remove one camp chair and it's fine! VW did replace our struts for brand new upgraded struts but to be honest I see no improvement with the new ones. The actual difference in the struts is minimal 1200nm standard and 1270nm upgrade.
bought these https://www.vandalierer.com/produkt/bikebrackets/